If you have any questions, please contact this email[email protected]

MORE PRODUCTS

  • EXPERMENAL STUDIES ON M20 GRADE CONCRETE BY

    Hard broken granite stones were used as a coarse aggregate in the concrete. The minimum Size of the coarse aggregate used in the investigations was 10 mm and maximum size should be 20 mm. The specific gravity of the coarse aggregate was found to be 2.69. 3.1.3 Fine aggregate:

  • (PDF) REPLACEMENT OF FINE AGGREGATE WITH SAWDUST

    In Group 3, waste aggregate has been used as a partial replacement of 10%, 15%, 20%, 25% and 30% by volume of coarse aggregate. The specimens were conditioned for 28-days at

  • Partial Replacement of Cement with Marble Dust and Fine ...

    10% is replaced in cement and stone dust used as partial replacement of fine aggregates: Figure – 4.3(iii) Compressive strength graph The concrete mix is prepared for M30 grade and cement is replaced by marble dust and fine aggregate with a stone dust as certain percentage. These are the graphs

  • (PDF) Comparative Study of M35 Concrete using Marble Dust ...

    Concrete is well known as a heterogeneous mixture of cement, water and aggregates. This paper helps to determine whether industrial wastes like marble dust can be satisfactorily used in concrete as a replacement of both cement and fine aggregate. The

  • Project on Partial Replacement of Cement with Marble Powder

    It is noticed that 5% replacement of cement with marble dust in mild condition and 10% replacement of cement with marble dust in severe conditions, are showing increase in tensile strength. (7)CONCLUSIONS: Due to marble dust, it proved to be very effective in assuring very good cohesiveness of mortar and concrete.

  • Partial Replacement of Cement With Marble Powder in Concrete

    The test results show that the compressive strength, split-tensile strength and flexural strengths are achieved up to 30% to 40% replacement of cement with marble powder without affecting the characteristic strength of M20(1:1.5:3) grade concrete. KEYWORDS: Cement (53 grade), Marble powder, Fine aggregate (M-sand), Coarse aggregate (20mm size).

  • (PDF) Comparative Study of M35 concrete using marble dust ...

    Comparative Study of M35 concrete using marble dust as a partial replacement of Cement and Fine aggregate Article (PDF Available) May 2017 with 577 Reads How we measure 'reads'

  • PARTIAL REPLACEMENT OF FINE AGGEREGATE WITH MARBLE

    reduce the strain on supply of natural fine aggregate, which will also reduce the cost of concrete. The main objective of the present investigation is to evaluate the possibilities of using Marble dust as a replacement to fine aggregate. Present investigation aimed at to study, 5%, 10%, 15%, 20%, 25%, 30%, 35% and 40% of traditional fine ...

  • Investigation on Strength Properties of Concrete with ...

    large number of marble dust and granite powder is generated in natural stone processing plants with an important impact on environment and humans. This project describes the feasibility of using the marble sludge and granite powder in concrete production as partial replacement of cement and fine aggregate.

  • Effect of Partial Replacement of Cement by Fly Ash and ...

    [1] Bahar Demirel “The Effect of the using waste marble dust as fine sand on the mechanical properties of the concrete ”International journal of physical Science Vol. 5(9),Pp. 1372-1380, 18 August,2010 Quarry dust and Marble sludge powder As Fine Aggregate ” Arpon Journal of

  • Author: Lokaesh Kumar, Gautam bhadoriya
  • EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF

    using quarry dust as a replacement to fine aggregate along with super plasticizer. The chemical admixture used for the investigation is super plasticizer compact sp430. 0%, 10%, 20%, 30%, 40%, 50% and 100% of traditional fine aggregate was replaced with quarry dust.

  • Performance of Marble Waste as Partially Replacement of ...

    marble dust as in place of fine aggregate in concrete ix and check the mechanical properties of mix. In this experimental study, the effects of using waste marble powder have been studied as a fine material on the mechanical properties of the concrete. Four different series of concretemixtures - were prepared by replacing the fine sand (passing

  • “Green Concrete: Using Industrial Waste of Marble Powder ...

    rock dust and marble sludge powder may be used as a replacement material for fine aggregate. The replacement of fine aggregate with 50% marble sludge powder and 50% Quarry rock dust (Green concrete) gives an excellent result in strength aspect and quality aspect.

  • EXPERIMENTAL STUDY ON CONCRETE BY PARTIAL

    cement with marble dust powder, fine aggregate with quarry dust, coarse aggregate with coconut shell. 2) To compare the compressive strength, flexural strength and split tensile strength with normal concrete. EXPERIMENTAL STUDY ON CONCRETE BY PARTIAL REPLACEMENT OF MARBLE DUST POWDER WITH CEMENT,QUARRY DUST WITH FINE AGGREGATE AND

  • replacement of fine aggregate with marble dust.pdf

    The replacement of fine aggregate with 50% marble sludge powder and . replacement of sand by marble powder pdf 80100TPH Stone replacement of sand by marble powder pdf partial replacement of sand with quarry dust pdf. replacement of fine aggregate with marble dust.pdf

  • Study of Properties of Concrete using Marble Powder and ...

    B. Fine Aggregate . Aggregates are important constituents in concrete. Manufacture sand was used as fine aggregate . TABLE 2 PROPERTIES OF FINE AGGREGATE SL.NO PROPERTY MAGNITUDE AND UNIT 1 Specific gravity 2.69 2 A.Sieve Analysis Zone II. 4 Bulk Density 1.22 5 Percentage Air Voids 54.44% 6 Water absorption 1.5% . C. Coarse Aggregate

  • Replacement of Fine Aggregates by Mixture of Ceramic

    partial and full replacement of fine aggregate by mixture of ceramic and marble powder in equal proportions. The reason for using ceramic and marble as fine aggregates is that both of them are waste materials in the form of broken insulators and marble chippings respectively, with marble powder also possessing cementitious properties.

  • (PDF) Effect of Partial Replacement of Cement by fly ash ...

    This Paper Presents the experimental study undertaken to investigate the influence of partial substitution of cement(opc) with Fly ash (FA), and partial substitution of fine aggregate by marble dust (MD) and stone dust(SD). Fly ash is a by product of

  • Partial Replacement of Fine Aggregates by Marble Powder

    used as the partial replacement of fine aggregates in concrete pavements. Marble powder is present abundantly and degrades the land on which it is laid. This paper reports the evaluation on the properties of marble dust. The marble dust used as fine aggregate in replacement of natural sand, as the sand is expensive because of the excessive cost of

  • Partial Replacement of Fine Aggregates with Quarry Dust ...

    Quarry dust and Marble powder are the most used among such materials to replace river sand, which can be used as alternative to fine aggregate in concrete. In the present investigation workability and strength of concrete was evaluated by replacement of natural sand by Quarry dust and marble powder in equal proportions of 0%, 10%, 20%,

  • EXPERIMENTAL INVESTIGATION ON PARTIAL

    were casted by replacement of cement by marble powder and quarry dust increasing the strength PHYSICAL COMPOSITIO MARBLE POWDER: FINE AGGREATE: Sand was collected from nearby river Zone-III is used as a fine aggregate is passed through the sieve of 4.75mm. IS: 383(1970) is followed for fine aggregate. AGGREGATE:

  • PARTIAL REPLACEMENT OF CEMENT WITH MARBLE DUST

    D, 2016 studied the impact of marble waste as coarse aggregate on properties of lean cement concrete. The main objective of this study was utilization of marble waste as a replacement for conventional natural coarse aggregate in concrete. Conventional natural aggregate was replaced by marble aggregate in different percentages 0-

  • PARTIAL REPLACEMENT OF FINE AGGREGATES WITH

    PARTIAL REPLACEMENT OF FINE AGGREGATES WITH QUARRY DUST AND MARBLE POWDER IN CONCRETE MERUVALA BHOPAL1, M.LAKSHMI2 1PG Student, Dept of CIVIL Engineering, SITE, Tirupati, AP, India. 2Assistant Professor, Dept of CIVIL Engineering, SITE, Tirupati, AP, India. Abstract- Quarry dust and Marble powder are the

  • Review on the feasibility of Marble Dust as Replacement of ...

    Earlier analysis conjointly indicate that the consequences of blending marble dust on the different properties of cement like setting times, consistency as well as soundness stay at intervals the appropriate ranges of various standards. It's been used as a replacement of fine aggregates as well as course aggregate in several literature

  • Partial Replacement of Fine Aggregates with Quarry Dust ...

    Quarry dust and Marble powder are the most used among such materials to replace river sand, which can be used as alternative to fine aggregate in concrete. In the present investigation workability and strength of concrete was evaluated by replacement of natural sand by Quarry dust and marble powder in equal proportions of 0%, 10%, 20%,

  • EXPERIMENTAL INVESTIGATION ON PARTIAL

    were casted by replacement of cement by marble powder and quarry dust increasing the strength PHYSICAL COMPOSITIO MARBLE POWDER: FINE AGGREATE: Sand was collected from nearby river Zone-III is used as a fine aggregate is passed through the sieve of 4.75mm. IS: 383(1970) is followed for fine aggregate. AGGREGATE:

  • PARTIAL REPLACEMENT OF CEMENT WITH MARBLE DUST

    D, 2016 studied the impact of marble waste as coarse aggregate on properties of lean cement concrete. The main objective of this study was utilization of marble waste as a replacement for conventional natural coarse aggregate in concrete. Conventional natural aggregate was replaced by marble aggregate in different percentages 0-

  • PARTIAL REPLACEMENT OF FINE AGGREGATES WITH

    PARTIAL REPLACEMENT OF FINE AGGREGATES WITH QUARRY DUST AND MARBLE POWDER IN CONCRETE MERUVALA BHOPAL1, M.LAKSHMI2 1PG Student, Dept of CIVIL Engineering, SITE, Tirupati, AP, India. 2Assistant Professor, Dept of CIVIL Engineering, SITE, Tirupati, AP, India. Abstract- Quarry dust and Marble powder are the

  • Review on the feasibility of Marble Dust as Replacement of ...

    Earlier analysis conjointly indicate that the consequences of blending marble dust on the different properties of cement like setting times, consistency as well as soundness stay at intervals the appropriate ranges of various standards. It's been used as a replacement of fine aggregates as well as course aggregate in several literature

  • EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY

    Study on Partial Replacement of Cement with Marble Powder And Fine Aggregate with Quarry Dust, International Journal of Civil Engineering and Technology, 8(6), 2017, pp. 774–781. [13] Y. Mahesh Babu and P. Sundara Kumar, Strength and Behavior of High Volume Fly Ash and Replacement of Sand by Quarry Dust.

  • AN EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT

    Apr 29, 2017  an experimental investigation on partial replacement of fine aggregate by waste marble powder - by m.prashanth, robin.b, ranganathan.c

  • 作者: prashanth bruce
  • CIVIL - EXPERIMENTAL PROJECTS - Majestic Project

    CIVIL - EXPERIMENTAL PROJECTS CEX001 . Experimental Investigation on Replacement of Sand by Graded Quarry Dust in Concrete ... Experimental Investigation on Partial Replacement of Fine Aggregate with Copper Slag ... Partial Replacement of Cement by Fly Ash and Sand by Marble Dust CEX013. Partial Replacement of Cement with Jute Fibre CEX014 ...

  • on replacement of stone dust in concrete and mortar

    on replacement of stone dust in concrete and mortar PDF...of replacement of natural sand by manufactured sand on the... :PDF/Adobe Acrobat-HTMLThe mortar exhibits excellent strength with 50% replacement of natural sand ...2004: carried out the tests on concrete with stone crusher dust as fine ...

  • PAPER OPEN ACCESS Related content Utilisation of Waste ...

    compared with conventional fine aggregate. Concrete specimen were cast using wmd in the laboratory with different proportion (25%, 50% and 100%) by weight of cement and from the studies it reveals that addition of waste marble dust as a replacement of fine aggregate marginally improves compressive, tensile and flexural strength in concrete ...

  • Experimental Utilization of Marble Dust Powder as Partial ...

    In the present experimental work, the natural fine aggregates are replaced by marble dust powder with replacement ratio of 0%, 25%, 50% and 100% and cement is replaced by marble dust with replacement ratio of 0%,5% and 10%. Twelve different mixes are used in the present study with varying replacement percentage of

  • Effects of Partial Replacement of Cement with Marble Dust ...

    Effects of Partial Replacement of Cement with Marble Dust Powder on Properties of Concrete Sonu Pal Amit Singh ... Tests of Fine Aggregate S. No. Test Fine Aggregate 1 Zone II 2 Moisture content 0.25% 3 Specific gravity 2.64 4 Bulk density 1.61 gm/cc 5 Fineness Modulus 2.42 ...

  • Experimental study on partial replacement of cement by ...

    Experimental study on partial replacement of cement by Marble Powder fine aggregate by Quarry Sand P.P.Shanbhag1, V.G.Patwari2 Department of Civil Engineering 1P.G. Student, ... Quarry dust is one such material which can be used to replace sand as fine aggregate. Quarry sand is a kind

  • Influence of Marble Dust as Partial Replacement of Cement ...

    alternative materials. Marble dust (MD) can be used as replacement for cement. B. Marble Dust About 68 million tons of marble solid dust is produced all over the world. It is the waste product formed in marble quarry and industries which may cause environmental pollution. And some of the chemical properties of marble dust are listed below.

  • Effects of Partial Replacement of Cement with Marble Dust ...

    Effects of Partial Replacement of Cement with Marble Dust Powder on Properties of Concrete Sonu Pal Amit Singh ... Tests of Fine Aggregate S. No. Test Fine Aggregate 1 Zone II 2 Moisture content 0.25% 3 Specific gravity 2.64 4 Bulk density 1.61 gm/cc 5 Fineness Modulus 2.42 ...

  • Influence of limestone waste as partial replacement ...

    Also, they concluded that the replacement of fine aggregate with 50% marble powder and 50% quarry rock dust gives an excellent result in tensile strength. V. Corinaldesi et al. [7] concluded that the marble powder proved to be very effective in assuring very good cohesiveness of mortar and concrete, even in the presence of a superplasticizing ...

  • OPTIMUM PARTIAL REPLACEMENT OF CEMENT IN

    replacement of fine aggregate. This study investigates the optimum partial replacement of cement in concrete with marble dust in conjunction with super-plasticizers. This investigation proved the feasibility of marble dust as an economic and eco-friendly replacement of cement. The slump and compressive strength of the concrete was

  • Influence of Marble Dust as Partial Replacement of Cement ...

    alternative materials. Marble dust (MD) can be used as replacement for cement. B. Marble Dust About 68 million tons of marble solid dust is produced all over the world. It is the waste product formed in marble quarry and industries which may cause environmental pollution. And some of the chemical properties of marble dust are listed below.

  • An Experimental Investigation on Strengths Characteristics ...

    fine and coarse aggregate and combining admixtures ... (2007) found that marble dust concrete has higher ... replacement of fine aggregate (sand).Different test such as sieve analysis values in Table 8 and different properties carried out in laboratory for stone dust are

  • ISSN 2348 – 7968 Replacement Of Cement By Marble Dust

    core compressive strength is attained at 10% replacement of marble dust concrete [17] -[18]. Satish et al [19], worked extensively on the hardened properties of bituminous concrete with marble dust as filler. Fillers are fine aggregate material that passes 0.063mm sieve [20]. The advancement of concrete technology can reduce the

  • A FEASIBLE STUDY ON WASTE FOUNDARY SAND AND

    This study indicates that the marble dust and WFS can be effectively replace Fine aggregate up to 20% in PQC mixtures. The highest flexural strength is achieved for the mix containing 10% marble dust and 20% WFS. The flexural strength increase is massive for mixes containing marble dust and WFS, with a combination up to certain

  • Experimental Study on concrete with Partial Replacement of ...

    Experimental Study on concrete with Partial Replacement of ...

  • Research Paper PARTIAL REPLACEMENT OF CEMENT WITH

    Research Paper PARTIAL REPLACEMENT OF CEMENT WITH MARBLE DUST POWDER Prof. P.A. Shirule a*, Ataur Rahman b , Rakesh D. Gupta c Address for Correspondence a*bc Dept. Of Civil Engineering, SSBT’s COET, Bambhori, Jalgaon, Maharashtra – 425001 ABSTRACT Leaving the waste materials to the environment directly can cause environmental problem.

  • EXPERIMENTAL INVESTIGATION OF PARTIAL

    Shirule et al: studied the ―Partial Replacement of cement with Marble Dust Powder‖. It can be concluded that for M20 grade concrete The It can be concluded that for M20 grade concrete The Compressive strength of Cubes are increased with addition of waste marble powder up to 10% replace by weight of cement and further any

  • EFFECT OF GROUNDNUT SHELL ASHAND MARBLE DUST AS

    The combination of groundnut shell ash (GSA) and marble dust (MD) were used to replace ordinary Portland cement at 0%, 5%, 10%, 15%, and 20% by weight of cement. Concrete cube with 0% of groundnut shell ash and marble dust serve as the control experiment. A 150mm x

  • Properties of Hardened Concrete Produced by Waste Marble ...

    Sand As Fine Aggregate Without Waste Marble The Concrete Compressive Strength Increased With The Increase Of Marble Dust Ratio As Sand Replacement Up To 15.0% Of Sand By Weight. Also, The Use Of Marble Dust As Sand Replacement Was More Effective With Lower W/C Ratio. Generally, The 10.0% Marble Dust Content As Sand Replacement Was Considered The

  • Comparative Analysis on Partial Replacement of Cement by ...

    with partial replacement of cement by Metakaolin and fine aggregate by Granite powder. The addition of Metakaolin along with cement has increased the compressive strength of the concrete when compared to the conventional concrete. The more effective percentage of replacement with Metakaolin seems to be between 10% and 15%.

  • partial replacement of cement with marble powder pdf

    5) P.Bhuvaneshwari An partial replacement of cement by with waste marble powder in Apr.2015 6) D.suji experimental study on concrete using waste marble powder and quarry dust as partial replacement of cement and fine aggregate” ISSN: 7607.

  • * *

    The materials of processing: *

    • Granite
    • Limestone
    • Basalt
    • Pebble
    • Gravel
    • Gypsum
    • Marble
    • Barite
    • Quartz
    • Dolomite
    • Gold Ore
    • Copper ore
    * *

    About US

    we in the more than 30 years of its development process, has formed a unique and content-rich corporate culture. The building of enterprise culture, particularly the aggregation of cohesion and solidarity, is built as power source for the sustainable development of enterprise.

    Copyright © 2004-2019 We All rights reservedsitemap