If you have any questions, please contact this email[email protected]

MORE PRODUCTS

  • Evaluation of Steel Industrial Slag as Partial Replacement ...

    Additionally, the replacement produces much dense microstructure [9]. Jalil et al. studied the effect of industrial steel slag as partial replacement of cement in concrete: They have reported that ...

  • Partial Replacement Of Fine Aggregate Using Steel Slag

    steel slag as partial replacement of fine aggregate. For this purpose different test on harden concrete were conducted at the age of 28 days like compressive strength on 150 x 150 x 150 mm size cube, splitting tensile strength on 150 mm X 300 mm cylinder,

  • GGBS as Partial Replacement of OPC in Cement Concrete – An ...

    The test results indicate that the ground granulated blast-furnace slag can be used with advantage as a partial to placement for portland cement in concrete at 50% or lower replacement levels ...

  • A STUDY ON PARTIAL REPLACEMENT OF CEMENT WITH

    granulated blast furnace slag is better replacement of cement than various other alternatives. The rateof strength gain in slag replaced concrete is slow in early stages but with proper curing the strength goes on increasing tremendously. The compressive strength decreases when the cement replacement is more than 50%. Use of slag or

  • Effect of Partial Replacement of Cement with Blast Furnace ...

    (replacement of sand by weight = 30% with Cast Iron Chips), 30% by weight of Blast Furnace Slag, replacing 30% of cement in the mix. The results recommend the use of Cast Iron Chips in concrete instead of sand use of Blast Furnace Slag instead of cement as well , up to certain level of replacement improves the

  • Author: Nalin Verma, Rajwinder Singh Bansal, Arun Verma, Musawir Quadir
  • Experimental Behavior of Reinforced Concrete with Partial ...

    Experimental Behavior of Reinforced Concrete with Partial Replacement of Cement with Ground Granulated Blast furnace Slag M. 1Ramalekshmi , R. Sheeja2, R. Gopinath3 1,2,Final Year Student, Department of Civil Engineering , Sathyabama University, Chennai, India. 3Assistant Professor, Department of Civil Engineering, Sathyabama University, Chennai, India.

  • Cited by: 1
  • Effect of blast furnace slag powder on compressive ...

    Compressive strength of blast furnace slag concrete with different dosage of slag was studied as a partial replacement of cement. From the experimental investigations, it has been observed that, the optimum replacement of Ground Granulated Blast Furnace Slag Powder to cement without changing much the compressive strength is 15%.

  • Utilization of Steel Slag in Concrete as a partial ...

    Utilization of steel slag in concrete as a partial replacement material for fine aggregates was studied by Kothai et al. [10], and found that fine aggregate replacement shows better workability ...

  • (PDF) Steel slag to improve the high strength of concrete

    The results were compared with conventional concrete property can be maintained with advanced mineral admixtures such as steel slag powder as partial replacement of cement 0 to 40%.

  • (PDF) Study on strength properties of concrete using GGBS ...

    Study on strength properties of concrete using GGBS and steel fiber as partial replacement of cement Article (PDF Available) in Journal of Industrial Pollution Control 33(1):1255-1259 October ...

  • (PDF) Study on strength properties of concrete using GGBS ...

    Study on strength properties of concrete using GGBS and steel fiber as partial replacement of cement Article (PDF Available) in Journal of Industrial Pollution Control 33(1):1255-1259 October ...

  • Effect of slag cement on the properties of ultra-high ...

    Slag cement, also known as ground granulated blast-furnace slag (GGBFS or GGBS), is a byproduct of the steel industry and commonly used supplementary cementitious material in concrete, either interground with Portland cement or as a partial replacement. The use of slag cement in ordinary concrete is accompanied by multiple benefits, such as ...

  • Replacement of Aggregates by Industrial Waste Steel Slag ...

    Osborne (1999): Durability of Portland blast furnace slag cement concrete,Cement and Concrete Composites ,vol 21,issue 1, 11- 21,1999. Ganesh Babu and Rama Kumar (2000): Efficiency of GGBS in concrete, Cement and concrete research, vol. 30, issue 7, 1031-1136.

  • An Experimental Study on Partial Replacement of Cement

    in concrete production as a partial replacement for Cement and sand. The cement has been replaced by GGBS in the range of 30%, 40% and 50% by weight of cement, quarry sand in the range of 40%, 50% and 60% by weight of cement for M40 grade mix. Workability test was carried out on

  • 1 APPLICATION OF STAINLESS STEEL SLAG WASTE AS A

    57 discussed about the application of stainless steel slag to cement material, but only with 58 10% of cement replacement [14]. 59 It is also possible to use Sw as a part of sand and cement in mortar manufacturing for 60 construction industry, replacing until 30% of cement [15]. In order to increase final

  • Experimental Analysis of Partial Replacement of Cement by ...

    The effect of GGBS and fly ash as partial cement replacement was examined on concrete cubes, cylinder and beams. In this research paper we have kept percentage of fly ash for every trial constant except for conventional trial and GGBS was used to replace cement partially from 40% up to 70% while keeping fly ash 25% as constant throughout.

  • Experimental Study on Concrete by Partially Replacing ...

    In each case the steel slag added as partial replacement of fine aggregate by 40% [12]. The mix design of M20 grade concrete is given in table no 6. Table no 6 Mix design of M20 grade concrete Water Cement Fine Aggregate Coarse Aggregate 197L 394kg 726.544kg 1314.88kg 0.5 1

  • Performance of concrete made with steel slag and waste ...

    Furthermore, partial replacement of cement with powder can lead to the improvement of concrete mechanical strength and durability , . Nonetheless, the main concern of using waste as aggregate in concrete is the possible alkali-silica reaction (ASR) between cement paste and aggregate which may result in excessive expansion and ...

  • Sustainable use of industrial-waste as partial replacement ...

    Waste foundry sand concrete up to 20% and steel slag concrete up to 50% replacement shows similar strength like control concrete. Palm oil clinker concrete up to 10% substitution exhibits more flexural strength than reference concrete. Download : Download high-res image (111KB) Download : Download full-size image; Figure 13. Flexural strength ...

  • Properties of Concrete Manufactured Using Steel Slag ...

    Various percentage of replacement Concrete with replacement Cement in % Fine aggregate in% Coarse aggregate in % River sand Steel slag Crushed Granite Steel slag 0% 100 100 0 100 0 30 % CA 100 100 0 70 30 40% FA 100 60 40 100 0 From the test results, the compressive strength of concrete increased 4.6% when the coarse aggregate is replaced by 30 ...

  • Slag Cement Benefits and Use in Concrete - Slag Cement News

    Slag cement is commonly found in ready-mixed concrete, precast concrete, masonry, soil cement and high temperature resistant building products. While there are many applications and benefits of slag cement, a few are highlighted below and detailed information sheets are located here.

  • STUDY ON STRENGTH PROPERTIES OF CONCRETE USING

    to conventional concrete. Various mix combinations with a partial replacement of 10%, 20%, 30% and 40% by the weight of cement by GGBS was taken and 0.5%, 1% and 1.5% steel fiber of hooked end type of aspect ratio 50-60 were used. The test results show that the partial replacement of cement by both GGBS and steel fiber has an increase in

  • Sustainable use of industrial-waste as partial replacement ...

    Waste foundry sand concrete up to 20% and steel slag concrete up to 50% replacement shows similar strength like control concrete. Palm oil clinker concrete up to 10% substitution exhibits more flexural strength than reference concrete

  • Slag Cement Benefits and Use in Concrete - Slag Cement News

    Slag cement is commonly found in ready-mixed concrete, precast concrete, masonry, soil cement and high temperature resistant building products. While there are many applications and benefits of slag cement

  • STUDY ON STRENGTH PROPERTIES OF CONCRETE USING

    to conventional concrete. Various mix combinations with a partial replacement of 10%, 20%, 30% and 40% by the weight of cement by GGBS was taken and 0.5%, 1% and 1.5% steel fiber of hooked end type of aspect ratio 50-60 were used. The test results show that the partial replacement of cement by both GGBS and steel

  • GGBS as a partial replacement to cement by Pavithra ...

    Apr 03, 2015  GGBS is a by-product of steel manufacturing industries and can also be used as partial replacement to cement.

  • 作者: U Me Oly
  • Steel-slag: a supplementary cementious ... - Global Cement

    Above - Table 1: Typical chemical compositions by percentage of steel-slag, ground granulated blast-furnace slag and clinker. 1 It can be seen that chemically steel-slag is much closer to OPC clinker than BFS. Usually alkalinity (R = CaO/SiO 2 or R= CaO/(SiO 2 +P 2 O 5)) is used to characterise a steel-slag

  • Evaluation of Steel Industrial Slag as Partial Replacement ...

    It is evaluated that cement is the second largest industrial source of CO2 on earth. This demands a partial or full replacement of cement by an environment-friendly material. In this research industrial waste slag from a local Steel Mill, namely Mangla Metals was selected as possible replacement of cement.

  • Partial Replacement of Cement with GGBS in Self

    Ground granulated blast furnace slag (GGBS) is used as fine partial replacement in the cement in Self compacting concrete. II. MATERIALS INVESTIGATION A. Cement The Ordinary Portland cement of 53-grade was used in this study conforming to IS: 12269-1987 .The specific gravity of cement

  • Waste powder as partial replacement of cement for ...

    At these stage 10, 15 and 25% cement replacement gave higher compressive strength than the control concrete while compressive strength with 20% cement replacement was found to be greatest. At 180 and 365 days the 20% added concrete gave 10% and 14% higher strengths respectively than control concrete.

  • EXPERIMENTAL INVESTIGATION ON COPPER SLAG AS FINE ...

    GGBS is used in this study for the partial replacement of Portland cement. GGBS is the by-product obtained during the manufacture of pig-iron. When coke, iron ores, and lime stone are sent into the furnace, the molten slag is obtained at the top layer of molten iron at a temperature of 15000C – 16000C. The slag

  • Behaviour and Experimental Study on Concrete as Partial ...

    Behaviour and Experimental Study on Concrete as Partial Replacement of Fine Aggregate with Copper Slag and Cement with GGBS ... is acquired by extinguishing liquid iron slag (a by-result of iron and steel-production) from an blast furnace in water or steam, to deliver a smooth, granular product that is ... 30% replacement of copper slag Cement ...

  • Ground granulated blast-furnace slag - Wikipedia

    Ground-granulated blast-furnace slag (GGBS or GGBFS) is obtained by quenching molten iron slag (a by-product of iron and steel-making) from a blast furnace in water or steam, to produce a y, granular product that is then dried and ground into a fine powder.Ground-granulated blast furnace slag

  • A Study On Durability Of Concrete By Partial Replacement ...

    A Study On Durability Of Concrete By Partial Replacement Of Cement With Steel Slag Powder Using Robo Sand 1 SHAIK YASEEN, 2 ... 10%, 20%, 30%and 40% of cement with Steel Slag powder

  • Vol. 3, Issue 4, April 2014 Utilization Of Steel Slag In ...

    Utilization Of Steel Slag In Concrete As A Partial Replacement Material for Fine Aggregates P.S.Kothai1 Dr.R.Malathy2 1Associate Professor, Department of Civil Engineering , Kongu

  • Which material can be used as replacement for sand in ...

    Aug 04, 2018  Granulated blast furnace slag ( GBFS) has been able to replace Sand to the amount of 70%. GBFS is byproduct of steel industry hence this method is feasible at location where steel plant is located in close proximity. Copper slag

  • STEEL SLAG AS REPLACEMENT OF FINE AGGREGATE IN

    concrete development. The present research work deals with a view to develop efficient concrete by addition of steel slag to evaluate the effectiveness of the use of steel slag as a partial replacement in sand To replace Sand with various percentages 10, 20, 30, 40% of steel slag waste in M25, M30 M35 concrete. Investigation have

  • Georgia Chapter ACI Luncheon Benefits of Slag Cement In ...

    furnace slag as a partial replacement for Portland cement in concrete if the following limits are met: a. Replace no more than 50 percent of the cement by weight. b. Replace the cement with slag at the rate of 1.0 lb (1.0 kg) of slag to 1.0 lb of cement.

  • Effects of Blast Furnace Slag as a Partial Replacement for ...

    A.O. Familusi; Effects of Blast Furnace Slag as a Partial Replacement for Cement in Concrete 233 Chemical Composition The microstructures and distribution of steel slag were studied with the aid of X-Ray Fluorescence spectrometer and X-Ray Diffractometer spectrometer that determined both chemical element and chemical composition.

  • EXPERIMENTAL INVESTIGATION ON REPLACEMENT OF

    EXPERIMENTAL INVESTIGATION ON REPLACEMENT OF CEMENT WITH FLY-ASH, STEEL SLAG, RED MUD IN CONCRETE C.Ashokraj1, P.Aathi kesavan2, A.Jagadeshwaran3, M.Karthick4 and S.Vinothkumar5 1,2,3,4,5 Department of Civil Engineering, The Kavery Engineering College Abstract—The concept of partial replacement of cement which is capable for reducing the emission

  • Experimental Investigation Of Coarse Aggregate With Steel ...

    study, finely powdered waste es are used as a partial replacement of cement in concrete and compared it with conventional concrete. This work examines the possibility of using Glass powder as a partial replacement of cement for new concrete. Glass powder was partially replaced as 10%, 20%, 30% and 40% and tested for its

  • Utilisation of silica fume steel slag in concrete as a ...

    Keywords: , steel slag concrete, steel slag, silica fume 1. Introduction 1.1 General Concrete is a mixture of cement, sand, coarse aggregate and water. Its success lies in its versatility as can be designed to withstand harshest environments while taking on the most inspirational forms.

  • The Behaviour of Concrete by Partial Replacement of Fine ...

    Brinda. D et al [4] investigated on various corrosion and durability tests on concrete containing copper slag as partial replacement of sand and cement. In this paper, M20 grade concrete was used and the tests were conducted for various proportions of copper slag replacement with sand of 0% to 60%, cement 0% to 20% and combination.

  • Effect of partial replacement of GGBS slag as fine ...

    Sep 29, 2018  IEEE Deepak S Mhatre. Effect of partial replacement of GGBS slag as fine aggregate and fly ash as cement on strength of concrete, International Journal of Advance Research, Ideas and Innovations in Technology, IJERnD. APA Deepak S Mhatre (2018). Effect of partial replacement of GGBS slag as fine aggregate and fly ash as cement on strength of concrete.

  • Particle Size Effect of Ground Granulated Blast Furnace ...

    Particle Size Effect of Ground Granulated Blast Furnace Slag (GGBS) in Cement Concrete V. Nagendra 1, C . Sashidhar 2, S . M . Prasanna Kumar 3, N .Venkata Ramana 4 1Civil Engineering Department, Nagarjuna College of E ngineering and Technology, Bengaluru, Karnataka, India . 2Civil Engineering Department, JNTUA ,Anantapur, A P, India .

  • Strength Analysis of Concrete by Using Iron Slag as a ...

    Keywords: Natural coarse aggregate, Iron slag, Iron slag aggregate, concrete, cement 1. Introduction Iron slag is a by-product of the iron and steel making process. Steel cannot be prepared in the Basic Oxygen Furnace (BOF) or in an Electric Arc Furnace (EAF) without making its by-product, steel slag [1]. The use of Iron slag aggregate in ...

  • Experimental Study on Partial Replacement of Fine ...

    partial replacement of fine aggregate by steel slag on the various strength properties of concrete by using the mix design of M20 grade. Test specimen with 0, 10, 20, 30, 4050% of partial replacement of fine aggregate by steel slag were cast and tested for compressive strength after

  • Use of Iron Slag as Partial Replacement of Sand to Concrete

    using slag replacement.” Cement and Concrete Vol. 30 pp 465-472. [2] A Guide to the Use of Iron and Steel Slag in Roads. Revision 2, (2002) Published by: Australasian Slag Association Inc. [3] Bilim C., Atis C. D., Tanyildizi H., Karahan O. (2008) “Predicting the Compressive Strength of Ground

  • A STUDY ON CONCRETE PROPERTIES USING STEEL SLAG AS PARTIAL ...

    This paper aims to study experimentally, the effect of partial replacement of coarse aggregate by steel slag (SS), on the various strength and durability properties of concrete, by using the mix design of M40 grade. In this study, steel slag was used

  • Strength development characteristics of concrete produced ...

    slag cement at higher temperatures was also used by studies in refs. [9–12]. In ref. [13], the author worked on the use of pelletised blast furnace slag and its effects on the freeze-and-thaw durability characteristics and reported its good performance in concrete. Although partial replacement of cement by reduced the cement consumption, it

  • * *

    The materials of processing: *

    • Granite
    • Limestone
    • Basalt
    • Pebble
    • Gravel
    • Gypsum
    • Marble
    • Barite
    • Quartz
    • Dolomite
    • Gold Ore
    • Copper ore
    * *

    About US

    we in the more than 30 years of its development process, has formed a unique and content-rich corporate culture. The building of enterprise culture, particularly the aggregation of cohesion and solidarity, is built as power source for the sustainable development of enterprise.

    Copyright © 2004-2019 We All rights reservedsitemap